Cub Cadet TANK 60 Operator's Manual download pdf (Page 29)

29se c t i O n 6 — Ma i n t e n a n c e & ad j u s t M e n t s

8.

oil cap from hydraulic reservoir for faster drainage. Remove

nut caps and drain oil from both left and right pumps.



Remove the three screws from the top of the oil filter and 

replace the oil filter element. Coat the sealing surface



screws back into the oil filter.

Add proper amount of hydraulic oil to reservoir.

Run and purge pumps and motors. Check oil level. 

Add proper amount of hydraulic oil to reservoir and repeat 



Hydraulic System

Hoses

Check the hoses from the hydraulic oil tank to the oil filter to

the hydraulic lines daily for leaks or abrasion and replace any

damaged hoses. Make certain there are no kinks or twists in any

hose. Look for a flattened condition or any leaks and repair or

replace as necessary. A flattened or leaking suction hose will

permit cavitation to develop which can destroy the pumps in a

short time.

Hydraulic Oil Tank and Filter

NOTE: 

hours of operation.

To drain the hydraulic oil tank:



bottom of the hydraulic oil tank.

Remove the drain plug, drain the tank, then replace the 2.

plug.



unscrewing in a counterclockwise direction. The filter will



to drain the rest of the hydraulic system.

4.

and lubricate the sealing surface.

5.

another one-half turn to seal.

NOTE: Always wipe off the hydraulic tank fill cap and the

area around it before removing the cap to prevent dirt

from contaminating the oil.

6.

oil selected for the filter until the oil level is up to the level

of the second hole in the fill tube. Leave this air space for

expansion.

7.

minutes. Check the filter for leaks. Idling the engine and

the pumps in this way will purge any air from the system.

8.

Top-off if necessary until the oil level is up to the second

hole in the fill tube.

NOTE: After unit is up to operating temperature, turn off

engine and re-check hydraulic oil. If oil appears foamy or



Contact service technician.

Contaminants or foreign matter in the oil will also damage the

pumps . To prevent this:







the hydraulic system. Thoroughly clean off any component

before you work on it.



or plastic plug.

Use plastic caps to seal off the ends of hydraulic fittings. 





Clean your hands frequently when working on the 

hydraulic components.

NOTE: The pumps are not owner-repairable. If a pump fails,



General Battery Information

WARNING!



the eyes or onto the skin, rinse the affected area

immediately with clean cold water. If there is any

further discomfort, seek prompt medical attention.

If acid spills on clothing, first dilute it with 

clean water, then neutralize with a solution of

ammonia/water or baking soda/water.

NEVER connect (or disconnect) battery 

charger clips to the battery while the charger is

turned on, as it can cause sparks.

Keep all sources of ignition (cigarettes, 

matches, lighters) away from the battery. The gas

generated during charging can be combustible.

Screw

Hydraulic Filter

Figure 6-2

1 2 ... 24 25 26 27 28 29 30 31 32 33 34 ... 47 48

Comments to this Manuals

No comments

Cub Cadet TANK 60 Operator's Manual Page 29

Comments to this Manuals

Related products and manuals for Tractor Cub Cadet TANK 60