Cub-cadet 3235 User Manual

IMPORTANT: READ SAFETY RULES AND INSTRUCTIONS CAREFULLYWarning: This unit is equipped with an internal combustion engine and should not be used on orn

10NOTE: References to LEFT andRIGHT indicate that side of the tractorwhen facing forward while seated inthe drivers seat. Reference to FRONTindicates

11Ignition / Light SwitchTo prevent accidental starting and/orbattery discharge, remove the keyfrom the ignition switch when thetractor is not in use.

12Seat Adjustment LeverThe seat adjustment lever is locatedbelow the seat. This lever is used toadjust the seat forward or backward. Differential Lock

13Indicator Light PodFigure 12 ABCDEABCDEOil Pressure IndicatorLow Fuel IndicatorHour MeterNot UsedNot UsedHour MeterThe hour meter is part of the in

14SECTION 7: OPERATIONSafety Interlock SwitchesThis tractor is equipped with a safetyinterlock system for the protection ofthe operator. If the interl

15• Place the PTO switch in the “OFF”position. Place the throttle controllever between the “MID” and “FAST”positions. Then turn the ignition keyto the

16Avoid stopping when driving up aslope. If it is necessary to stop whiledriving up a slope, start up smoothlyand carefully to reduce the possibilityo

17For best results it is recommended thatthe first two laps should be cut with thedischarge thrown towards the center.After the first two laps, revers

18For the comfort of the operator, this trac-tor is equipped with an adjustable tiltsteering wheel. To adjust the steeringwheel: push the steering whe

19From just above the right axle carrier,inside the right frame rail, slowly turnthe hex nylon lock nut at the end ofthe brake rod as follows to adjus

2TABLE OF CONTENTSPAGETRACTOR PREPARTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2IMPORTANT SAFE OPERATION PRAC

20LUBRICATION ILLUSTRATIONCub Cadet 251H EP Greaseor equivalent No. 2 lithium greaseEngine Oil: See Figure 27 on page 30Transmission Oil - Cub Cadet D

21Accessing Engine CompartmentThe engine compartment can beaccessed by raising the hood asfollows:• Lift the hood straight upward at therecessed notch

22immediately with clean cold water. Ifthere is any further discomfort, seekprompt medical attention.• If acid spills on clothing, first dilute itwith

23Headlight Bulb ReplacementReplace headlight bulbs as follows:(See Figure 20)1. After noting which wire connectsto each terminal, unplug the wirehar

24must be withdrawn and wiped clean,then fully reinserted before beingwithdrawn again for a true reading.Figure 21 Adding Transmission OilWARNING: Th

25Figure 22 • Clean around the base of the trans-mission oil filter and remove thefilter by turning it counterclockwise.• Apply a light coating of cl

26FuseFuses are installed to protect the trac-tor’s electrical system from damagecaused by excessive amperage.Always use the same capacity fuse forrep

27SECTION 10: ENGINE INFORMATIONKOHLER CO.FEDERAL AND CALIFORNIA EMISSION CONTROL SYSTEMSLIMITED WARRANTYSMALL OFF-ROAD EQUIPMENT ENGINESThe U.S. Envi

28LIMITATIONSThis Emission Control System Warranty shall notcover any of the following:(a) repair or replacement required because ofmisuse or neglect,

29Cleaning The EngineThis tractor has an air-cooled engine.Air must be able to circulate freelyaround the engine through theflywheel screen, through t

31. GENERAL OPERATION• Read, understand, and follow allinstructions in the operator’s manualand on the machine before starting.Keep this manual in a

30Refer to Figure 27 for informationregarding the proper type of oil to addto the crankcase.• Place the tractor on a level surfaceand engage the parki

31• Attach the flexible tubing to thedrain valve. Place an appropriatecontainer below the open end of thetubing to collect the old oil.• To open the d

32WARNING: Operating theengine with loose or dam-aged air cleaner componentswill allow unfiltered air intothe carburetor, causing ex-tensive wear and

33SECTION 11: TROUBLE SHOOTINGPossible Cause Possible RemedyHard To StartNo fuel in fuel tank or carburetor Fill the tank with fuel. Check the fuel li

34Fuel tank air vent clogged Remove obstruction from the vent in the fuel tank cap.Air leakage between carburetor and engine Remove air cleaner. Tight

35SECTION 12: OPTIONAL EQUIPMENTWhen you purchased your tractor, you probably had it completely equipped foryour particular needs at that time. Howeve

36SECTION 13: SPECIFICATIONSEngineManufacturer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . KohlerHorsepower .

37SECTION 14: SLOPE GAUGEWARNING: Do not mow on inclines with a slope in excess of 15degrees (a rise of approximately 2-1/2 feet every 10 feet). A ri

38

39CUB CADET LLCMANUFACTURER’S ONE YEAR LIMITED WARRANTY(COMMERCIAL USE)The limited warranty set forth below is given by CUB CADET LLC (“CUB CADET”)wit

4• Never leave a running machineunattended. Always turn off blade(s),place transmission in neutral, setpark brake, stop engine and removekey before di

40The provisions as set forth in this Warranty provide the sole and exclusiveremedy arising from the sale. CUB CADET shall not be liable for inciden

41CUB CADET LLCMANUFACTURER’S LIMITED WARRANTY(RESIDENTIAL USE)The limited warranty set forth below is given by CUB CADET LLC (“CUB CADET”)with respec

42This limited warranty does not provide coverage in the following cases:a. Routine maintenance items such as lubricants, filters, blade sharpeningand

43

SECTION 15: QUICK REFERENCE PARTSDescription Part NumberEngine Oil 737-3030A (10W30)737-3049 (5W30)Air Filter KH-47-083-03KH-24-083-02Engine Oil Fil

5• Use extra care with grass catchersor other attachments. These canchange the stability of the machine.• Keep all movement on the slopesslow and grad

6• To reduce fire hazard, keep themachine free of grass, leaves orother debris build-up. Clean up oil orfuel spillage. Allow machine to coolat least 5

7SECTION 3: CALLING SERVICE INFORMATIONThe engine manufacturer is responsible for all engine-related issues withregards to performance, power-rating,

8SECTION 5: SAFETY LABELS FOUND ON YOUR UNITFigure 2 AVO ID SERIOUS INJURY OR DEATHREAD OPERATOR'S MANUALWARNINGGO UP AND DOWNSLOPES, NOT ACR

9SECTION 6: CONTROLSFigure 3