Cub Cadet EX2900 Operator's Manual

1-21. SAFETY PRECAUTIONSEx2900 / 3200 Operator's ManualIndicates a hazardous situation which, if not avoided, will result in death or serious inj

14-1814. PERIODIC SERVICEEx2900 / 3200 Operator's Manual1. Lubricating Grease Fittings on the Tractor[Extremely wet or muddy conditions]Lubricate

14-1914. PERIODIC SERVICEEx2900 / 3200 Operator's Manual2. Lubricating the Hydraulic Implement Control Valve Linkage(A) Lubricate the implement c

14-2014. PERIODIC SERVICEEx2900 / 3200 Operator's Manual Servicing the Fan and Alternator BeltBe careful to avoid injury:●Fingers or loose cloth

14-2114. PERIODIC SERVICEEx2900 / 3200 Operator's Manual8. Remove the belt from the alternator sheave, fan sheave and crankshaft sheave.9. Route

14-2214. PERIODIC SERVICEEx2900 / 3200 Operator's Manual Servicing the Air Filter ElementBe careful to avoid injury:●Touching hot surfaces can l

14-2314. PERIODIC SERVICEEx2900 / 3200 Operator's Manual8. Reinstall the air cleaner element.If necessary, remove and discard the old primary ele

14-2414. PERIODIC SERVICEEx2900 / 3200 Operator's Manual Cleaning the Fuel / Water Separator and Replacing the Fuel FilterAvoid injury:●Remember

14-2514. PERIODIC SERVICEEx2900 / 3200 Operator's Manual Engine OilUse an oil of the viscosity appropriate for the air temperature range expecte

14-2614. PERIODIC SERVICEEx2900 / 3200 Operator's Manual10. Apply a small amount of clean engine oil onto the gasket of the new filter.11. Instal

14-2714. PERIODIC SERVICEEx2900 / 3200 Operator's Manual Transmission OilIMPORTANT:●Make sure to use Cub Cadet Hydraulic / Transmission Fluid fo

1-31. SAFETY PRECAUTIONSEx2900 / 3200 Operator's Manual1. Understand the performance and limitations of your tractor. Carefully study this operat

14-2814. PERIODIC SERVICEEx2900 / 3200 Operator's Manual4. Turn the transmission oil filter with the filter wrench to remove.5. Install a new tra

14-2914. PERIODIC SERVICEEx2900 / 3200 Operator's Manual Front Axle Case OilIMPORTANT:●Make sure to use Cub Cadet GEAR LUBE or SAE 80W-90 gear o

14-3014. PERIODIC SERVICEEx2900 / 3200 Operator's Manual Replacing the Fuel FilterAvoid injury:●Remember that vapor from diesel fuel is explosiv

14-3114. PERIODIC SERVICEEx2900 / 3200 Operator's Manual Servicing the Cooling SystemAvoid injury. ●ALWAYS allow radiator to cool before removin

14-3214. PERIODIC SERVICEEx2900 / 3200 Operator's Manual2. Flushing the Cooling System1. Fill the cooling system with water and common flushing /

14-3314. PERIODIC SERVICEEx2900 / 3200 Operator's Manual Recommended Engine CoolantAvoid injury:●Fluids released under pressure from the cooling

14-3414. PERIODIC SERVICEEx2900 / 3200 Operator's ManualNOTE: ●Replace the air cleaner element at least once a year.●Replace the cooler flushing

15-115. SERVICING THE ELECTRICAL SYSTEMEx2900 / 3200 Operator's Manual15.SERVICING THE ELECTRICAL SYSTEM●To avoid personal injury, do as follows:

15-215. SERVICING THE ELECTRICAL SYSTEMEx2900 / 3200 Operator's Manual Servicing the Battery SafelyAvoid personal injury. The battery electrolyt

15-315. SERVICING THE ELECTRICAL SYSTEMEx2900 / 3200 Operator's Manual Inspecting the BatteryThe battery used on your tractor is a maintenance-f

1-41. SAFETY PRECAUTIONSEx2900 / 3200 Operator's Manualsneakers. Wear additional protections including non-slip safety boots or shoes, and safety

15-415. SERVICING THE ELECTRICAL SYSTEMEx2900 / 3200 Operator's Manual2. Installing the Battery1. Install the battery onto the tractor.2. Inspect

15-515. SERVICING THE ELECTRICAL SYSTEMEx2900 / 3200 Operator's Manual Using a Booster BatteryAvoid personal injury:●NEVER attempt to jump-start

15-615. SERVICING THE ELECTRICAL SYSTEMEx2900 / 3200 Operator's ManualIMPORTANT: Avoid damage.●Use of a fuse other than a correctly rated one may

15-715. SERVICING THE ELECTRICAL SYSTEMEx2900 / 3200 Operator's Manual Replacing the Headlight BulbIMPORTANT: Avoid damage.●NEVER touch the head

15-815. SERVICING THE ELECTRICAL SYSTEMEx2900 / 3200 Operator's Manual Replacing the Tail Light BulbNOTE:●The tail light can be serviced after r

15-915. SERVICING THE ELECTRICAL SYSTEMEx2900 / 3200 Operator's Manual Replacing the Instrument Panel Light Bulb1. Park your tractor safely. 2.

16-116. STORAGEEx2900 / 3200 Operator's Manual16. STORAGEBe careful to avoid injury:●Remember that vapor from diesel fuel is explosive and flamma

16-216. STORAGEEx2900 / 3200 Operator's Manual2. Preparing the Fuel and Engine for Storage FuelIf using stabilized fuel, fully fill the fuel tan

16-316. STORAGEEx2900 / 3200 Operator's Manual1. Check the tire pressure. If necessary, refill with compressed air.2. Check the levels of engine

17-117. TROUBLESHOOTINGEx2900 / 3200 Operator's Manual17. TROUBLESHOOTINGThe troubleshooting table given below is intended to provide a simple gu

1-51. SAFETY PRECAUTIONSEx2900 / 3200 Operator's Manual8. Avoid accidental contact with control pedals while the engine is running, as this can c

17-217. TROUBLESHOOTINGEx2900 / 3200 Operator's Manual2. Machine6 The engine overheats.z Insufficient engine coolant • Add engine coolant.• Check

17-317. TROUBLESHOOTINGEx2900 / 3200 Operator's Manual3. Brake4. SteeringSymptom Cause Remedy1 Brake does not function correctly.z Misadjusted br

18-118. INDEXEx2900 / 3200 Operator's Manual18. INDEX3-Point Hitch Control Lever ... 5-2, 10-14-Wheel Drive Lever ...

1-61. SAFETY PRECAUTIONSEx2900 / 3200 Operator's ManualOn a slope, the tractor is less stable and more prone to tip-over, possibly leading to ser

1-71. SAFETY PRECAUTIONSEx2900 / 3200 Operator's Manual1. Disengagement of the 4-wheel drive is recommended.2. Remember that the braking characte

1-81. SAFETY PRECAUTIONSEx2900 / 3200 Operator's Manual1. Before getting off the tractor, connecting/ disconnecting an implement, adjusting, clea

1-91. SAFETY PRECAUTIONSEx2900 / 3200 Operator's ManualBefore starting any servicing work, park your tractor on solid, level ground, engage the p

1-101. SAFETY PRECAUTIONSEx2900 / 3200 Operator's Manual16. Avoid working under any hydraulically supported devices. Such devices can settle, sud

1-111. SAFETY PRECAUTIONSEx2900 / 3200 Operator's Manual Safety-Alert SymbolThe tractor safety decals illustrated in this section are provided i

1-121. SAFETY PRECAUTIONSEx2900 / 3200 Operator's Manual(A) CY1A8160-85170WARNINGThis structure's protective capability may be impaired by

1-131. SAFETY PRECAUTIONSEx2900 / 3200 Operator's Manual(D) CY1A8160-65310WARNINGTO AVOID INJURY:Before leaving or servicing machine,●Stop engine

1-141. SAFETY PRECAUTIONSEx2900 / 3200 Operator's Manual(H) CY1A8160-65300DANGERTO AVOID INJURY OR DEATH:●Do not start engine by shorting across

1-151. SAFETY PRECAUTIONSEx2900 / 3200 Operator's Manual(J) CY198220-65621WARNINGAVOID INJURY FROM PTO:●Keep all shields in place.●Keep hands, f

2-12. SERVICING THE TRACTOREx2900 / 3200 Operator's Manual2. SERVICING THE TRACTORYour Cub Cadet Yanmar dealer wants to remain committed to the t

3-13. SPECIFICATIONSEx2900 / 3200 Operator's Manual3. SPECIFICATIONS1. Specifications TableModel Ex2900 Ex3200Power Take Off (PTO) Power hp (kW)

3-23. SPECIFICATIONSEx2900 / 3200 Operator's ManualTravelingSystemTireAg (R1)Front 7-14Rear 11.2-24Turf (R3)Front 25×8.50-14Rear 13.6-16Industria

4-14. IMPLEMENT CAPACITIESEx2900 / 3200 Operator's Manual4. IMPLEMENT CAPACITIESThe Cub Cadet Yanmar tractor has been carefully tested in the con

4-24. IMPLEMENT CAPACITIESEx2900 / 3200 Operator's ManualImplement Remarks Unit AmountTrailerMaximum Load Capacity lb (kg) 2200 (1000)Maximum Dra

5-15. NAMES AND FUNCTIONS OF COMPONENTSEx2900 / 3200 Operator's Manual5.NAMES AND FUNCTIONS OF COMPONENTS(1) Headlights(2) Hood(3) Fuel inlet(4)

1Ex2900 / 3200 Operator’s ManualINTRODUCTIONThank you for purchasing our tractor product that has been designed and manufactured based on our state-of

5-25. NAMES AND FUNCTIONS OF COMPONENTSEx2900 / 3200 Operator's Manual(1) Multi-function switch(2) Headlight switch(3) Hazard lights button switc

5-35. NAMES AND FUNCTIONS OF COMPONENTSEx2900 / 3200 Operator's Manual(1) Fuel GaugeThis gauge indicates level of fuel in the fuel tank.(2) Tacho

5-45. NAMES AND FUNCTIONS OF COMPONENTSEx2900 / 3200 Operator's Manual(8) Headlight / Turn Signal SwitchUse the blue lever to turn ON/OFF the hea

6-16. PRE-OPERATION CHECKEx2900 / 3200 Operator's Manual6. PRE-OPERATION CHECK●Check the tractor for damage, excessive wear, cracks, missing part

7-17. OPERATING THE ENGINEEx2900 / 3200 Operator's Manual7. OPERATING THE ENGINENEVER run or idle the engine in a confined area that is poorly ve

7-27. OPERATING THE ENGINEEx2900 / 3200 Operator's Manual2. Engage the parking brake securely. Engaging the Parking Brake1. Pull up the parking

7-37. OPERATING THE ENGINEEx2900 / 3200 Operator's Manual6. If the tractor has any implements that use the implement control valve, lower them t

7-47. OPERATING THE ENGINEEx2900 / 3200 Operator's Manual9. Turn the starter key switch to the START position.(A) OFF position:The engine must no

7-57. OPERATING THE ENGINEEx2900 / 3200 Operator's Manual Checking the Lights on the Instrument Panel1. When the parking brake is in the locked

7-67. OPERATING THE ENGINEEx2900 / 3200 Operator's ManualUse the glow plug when the air temperature is 23°F (–5°C) or lower.1. Move the key switc

2Ex2900 / 3200 Operator's ManualTABLE OF CONTENTS1. About This Manual ...

7-77. OPERATING THE ENGINEEx2900 / 3200 Operator's Manual1. Remove foot from the forward and reverse drive pedals.2. Run the engine at a lowest p

7-87. OPERATING THE ENGINEEx2900 / 3200 Operator's ManualIMPORTANT: Avoid engine damage.●If the engine stalls while operating under load, immedia

8-18. OPERATING THE TRACTOREx2900 / 3200 Operator's Manual8. OPERATING THE TRACTORALWAYS use the drawbar to tow an implement. NEVER attach a load

8-28. OPERATING THE TRACTOREx2900 / 3200 Operator's ManualThe service life of the tractor is governed by how adequately it is handled and maintai

8-38. OPERATING THE TRACTOREx2900 / 3200 Operator's ManualAvoid injury:●NEVER operate the tractor with the Roll-Over Protective Structure (ROPS)

8-48. OPERATING THE TRACTOREx2900 / 3200 Operator's Manual2. Raising (Unfolding) the Roll-Over Protective Structure (ROPS)1. Pull out the cotter

8-58. OPERATING THE TRACTOREx2900 / 3200 Operator's ManualAvoid injury:●Before starting or operating the tractor, always check the area around th

8-68. OPERATING THE TRACTOREx2900 / 3200 Operator's Manual Fastening the Retractable Seat BeltAvoid injury:●ALWAYS keep the retractable seat bel

8-78. OPERATING THE TRACTOREx2900 / 3200 Operator's Manual HeadlightsMove the headlight lever up to turn OFF the headlights, and down to turn ON

8-88. OPERATING THE TRACTOREx2900 / 3200 Operator's Manual 4-Wheel Drive LeverIn the 4-wheel drive mode, all the four wheels are powered to obta

3TABLE OF CONTENTSEx2900 / 3200 Operator's Manual3. Shutting Down the Engine...

8-98. OPERATING THE TRACTOREx2900 / 3200 Operator's Manual6. Raise the implement.1. Move the 3-point hitch control lever backward to raise the im

8-108. OPERATING THE TRACTOREx2900 / 3200 Operator's Manual Drive PedalsThe tractor accelerated speed depends on how far the drive pedal is pres

8-118. OPERATING THE TRACTOREx2900 / 3200 Operator's Manual Engaging the Cruise Control1. Depress the forward drive pedal until an intended trav

8-128. OPERATING THE TRACTOREx2900 / 3200 Operator's ManualAvoid injury:●Slow down before making a turn.1. Release the forward / reverse drive pe

8-138. OPERATING THE TRACTOREx2900 / 3200 Operator's Manual Engaging the Parking BrakeAvoid injury:●ALWAYS engage the parking brake securely bef

8-148. OPERATING THE TRACTOREx2900 / 3200 Operator's Manual1. Differential Lock(A) Differential lock foot pedalAvoid injury. To prevent tipping o

8-158. OPERATING THE TRACTOREx2900 / 3200 Operator's Manual2. Safely Driving the Tractor on RoadsAvoid injury. Be cautious when driving the tract

8-168. OPERATING THE TRACTOREx2900 / 3200 Operator's Manual●Strictly observe all the currently effective local traffic and safety laws and regula

8-178. OPERATING THE TRACTOREx2900 / 3200 Operator's Manual4. Transporting the Tractor on a TrailerAvoid injury:●Exercise extreme care when loadi

8-188. OPERATING THE TRACTOREx2900 / 3200 Operator's Manual●Before approaching a slope, select an appropriate speed setting. NEVER shift on a slo

4Ex2900 / 3200 Operator's ManualTABLE OF CONTENTS2. Drawbar...

8-198. OPERATING THE TRACTOREx2900 / 3200 Operator's Manual1. Before approaching a slope, select a lower gear setting.(A) Range shift lever(a) Sh

9-19. POWER TAKE OFF (PTO)Ex2900 / 3200 Operator's Manual9. POWER TAKE OFF (PTO)ALWAYS ensure all moving components have stopped rotating before

9-29. POWER TAKE OFF (PTO)Ex2900 / 3200 Operator's Manual Engaging the Power Take Off (PTO) (when the operator is seated on the operator's

9-39. POWER TAKE OFF (PTO)Ex2900 / 3200 Operator's Manual Disengaging the Power Take Off (PTO) (when the operator is seated on the operator&apos

9-49. POWER TAKE OFF (PTO)Ex2900 / 3200 Operator's ManualFollow the instructions below when using the Power Take Off (PTO) when the tractor is in

9-59. POWER TAKE OFF (PTO)Ex2900 / 3200 Operator's Manual4. Move each Power Take Off (PTO) engagement lever to the OFF position. (A) Rear Power T

10-110. 3-POINT HITCH AND DRAWBAREx2900 / 3200 Operator's Manual10. 3-POINT HITCH AND DRAWBARALWAYS install an appropriate counterbalance to the

10-210. 3-POINT HITCH AND DRAWBAREx2900 / 3200 Operator's Manual2. Using the 3-Point Hitch Adjusting the Right Lift Link1. Lower the rear-mounte

10-310. 3-POINT HITCH AND DRAWBAREx2900 / 3200 Operator's ManualThe drawbar has two adjusting holes that allow the user to adjust the drawbar len

10-410. 3-POINT HITCH AND DRAWBAREx2900 / 3200 Operator's ManualAvoid injury:●Only hitch a towed load to the drawbar to avoid tip over. NEVER use

5TABLE OF CONTENTSEx2900 / 3200 Operator's ManualChecking the Fuel line ...

11-111. HYDRAULIC SYSTEMEx2900 / 3200 Operator's Manual11. HYDRAULIC SYSTEMALWAYS fully release the internal hydraulic pressure before disconnect

11-211. HYDRAULIC SYSTEMEx2900 / 3200 Operator's Manual Hydraulic Flow Control / Stop Knob●Lowering the 3-point hitch too fast can lead to accid

11-311. HYDRAULIC SYSTEMEx2900 / 3200 Operator's Manual Implement Control Lever(A) Implement control leverThese couplers are used in pairs of 1

11-411. HYDRAULIC SYSTEMEx2900 / 3200 Operator's Manual1. Using the Hydraulic Lock LeverUse the hydraulic lock lever to adjust the shift directio

11-511. HYDRAULIC SYSTEMEx2900 / 3200 Operator's ManualAvoid injury:●Escaping high pressure oil can penetrate the skin and cause severe injury. A

12-112. TIRES, WHEELS AND BALLASTEx2900 / 3200 Operator's Manual12.TIRES, WHEELS AND BALLASTNEVER attempt to mount a tire on a rim. Contact a rep

12-212. TIRES, WHEELS AND BALLASTEx2900 / 3200 Operator's ManualEach tire size has specific adjustment settings that must not be changed. Checki

12-312. TIRES, WHEELS AND BALLASTEx2900 / 3200 Operator's Manual Tread Centerline Width <Front Wheels>Wide and extra wide are achieved by

12-412. TIRES, WHEELS AND BALLASTEx2900 / 3200 Operator's Manual Front BallastTo improve stability and traction, add ballast as needed. Heavy pu

12-512. TIRES, WHEELS AND BALLASTEx2900 / 3200 Operator's Manual Maximum WeightUsually, five 44 lb (20 kg) weights can be installed on the tract

6Ex2900 / 3200 Operator's ManualTABLE OF CONTENTS Checking the Fuel Injection Pump ...

13-113. MAINTENANCEEx2900 / 3200 Operator's Manual13. MAINTENANCE●For the checkpoints (✔) listed below, check and service at the intervals indica

13-213. MAINTENANCEEx2900 / 3200 Operator's ManualFor assistance in periodic maintenance procedures, contact your local Cub Cadet Yanmar dealer.(

13-313. MAINTENANCEEx2900 / 3200 Operator's Manual1. Technical Document[U.S.A. and Canada]When wanting to obtain a copy of Parts Catalog or Techn

14-114. PERIODIC SERVICEEx2900 / 3200 Operator's Manual14. PERIODIC SERVICEExplosion HazardNEVER smoke around the battery or during refueling. Ke

14-214. PERIODIC SERVICEEx2900 / 3200 Operator's Manual1. Opening / Closing the Hood●Do not open the hood while the engine is running.●Do not tou

14-314. PERIODIC SERVICEEx2900 / 3200 Operator's Manual Closing the Hood1. Lift up the hood slightly, grasp the grip at the middle of the hood s

14-414. PERIODIC SERVICEEx2900 / 3200 Operator's Manual Checking the Engine Oil LevelIMPORTANT: Avoid damage.●ALWAYS check the oil level daily.

14-514. PERIODIC SERVICEEx2900 / 3200 Operator's Manual Inspecting the Transmission Oil Level1. Park the tractor safely. Allow the tractor to co

14-614. PERIODIC SERVICEEx2900 / 3200 Operator's ManualSpecified Torque(A) Rim(B) Axle(C) Bolt fixing the rim to the disk (Only R1 tire)(D) Bolt

14-714. PERIODIC SERVICEEx2900 / 3200 Operator's Manual Checking and Adjusting the Clutch1. Stop the tractor, and chock the tires.2. Shut down t

1-11. SAFETY PRECAUTIONSEx2900 / 3200 Operator's Manual1. SAFETY PRECAUTIONSThis operator’s manual presents you messages that help you remain awa

14-814. PERIODIC SERVICEEx2900 / 3200 Operator's Manual Checking the Tire Air PressureAdjust the front and rear tires to the standard pressure.

14-914. PERIODIC SERVICEEx2900 / 3200 Operator's Manual Cleaning the Radiator Cooling Screen, Cooling Fins and Oil Cooler PipeAvoid injury. Comp

14-1014. PERIODIC SERVICEEx2900 / 3200 Operator's Manual Cleaning the Grille and Side ScreensIMPORTANT: Avoid damage.●Clean the grille and side

14-1114. PERIODIC SERVICEEx2900 / 3200 Operator's Manual Checking the Cooling SystemAvoid injury. ●ALWAYS allow radiator to cool before removing

14-1214. PERIODIC SERVICEEx2900 / 3200 Operator's Manual Refilling the Fuel TankIMPORTANT: Avoid damage.●NEVER use a galvanized container to sto

14-1314. PERIODIC SERVICEEx2900 / 3200 Operator's Manual1. Park the tractor safely.2. Allow the engine to cool off for several minutes before ref

14-1414. PERIODIC SERVICEEx2900 / 3200 Operator's Manual1. Range Shift Lever Neutral Switch1. Sit on the operator’s seat.2. Disengage the Rear Po

14-1514. PERIODIC SERVICEEx2900 / 3200 Operator's Manual3. Rear Power Take Off (PTO) Engagement Lever Switch1. Sit on the operator’s seat.2. If t

14-1614. PERIODIC SERVICEEx2900 / 3200 Operator's Manual5. Checking the Operation of the Seat Safety Switch1. Move the range shift lever into the

14-1714. PERIODIC SERVICEEx2900 / 3200 Operator's Manual Checking the Front Axle Oil LevelIMPORTANT: Avoid damage.●Before checking the oil level